A I find no information in my ALLDATA automotive database regarding potential oil pump failures in the 3-liter V6 engine. This engine has been a very durable workhorse for Ford for several decades.
The only way an oil pump could "fail without warning" would be if the drive shaft or impeller suddenly broke or if the oil pump pickup tube fell out and dropped into the oil pan. In addition, I didn't find an updated oil pump from Ford for this engine, so unless you installed an aftermarket pump you'd be installing the same pump you're worried about. From a cost point of view, replacing the oil pump would be roughly $500 in parts and labor, more than I'd be willing to spend in terms of preventive maintenance.
Q I have a 2010 Chevrolet Impala and I absolutely love the car. I have had the car for almost two years and have never had any issues with the remote starter until this winter. The car starts fine, but by the time I get behind the wheel it is still blowing cold air even though the thermostat shows it is warmed up. It doesn't start blowing hot air from the heater until I put the car in gear and start driving. Then the heat starts pouring out almost immediately.
A The most common cause for lack of heat at idle is low coolant, so check the coolant level when the engine is cold. When the coolant level is low, there's limited circulation through the heater core until the engine rpm increases and the water pump circulates more hot coolant through the heater core. The same symptom would occur if the thermostat has not reached opening temperature -- roughly 195 degrees -- even if it showed a relatively warm engine on the water temperature gauge.
Q I have a 1998 Chrysler Concorde with 163,000 miles on it. Several years ago, I noticed that when I turned the headlights on when it was overcast or in a light rain, they would occasionally flicker on and off. If I reached down and tapped the headlight switch when they flickered off, they would come back on. Here's the clincher -- they have never done this at night. They stay on rock- steady when it is dark. Any ideas?
A Since the flickering occurs only during daylight hours, the problem is likely in the daytime running lights (DRL) system. When the ignition key is turned to the "on" position, the headlights will illuminate at a reduced voltage level. When the headlights are switched on at night, or if the automatic headlight system recognizes low light situations, the headlights switch to full illumination. Under no conditions should the headlights flicker completely off.
Any fault -- a short or "open" -- in the input to the headlight switch will cause the switch to default to the "headlights on" mode. Since the headlights flicker on and off, the switch itself might be suspect. A scan tool might identify a fault code from the body control module (BCM), which controls the headlights.
Q I have a 2002 Buick Century. The light that illuminates both the odometer and gear indicator on the dash became dimmer and dimmer and finally this summer went completely out. Do you have any inexpensive suggestions?
A My suggestions are always inexpensive -- free, in fact! The individual "peanut" lamps in the instrument cluster are replaceable. The cluster is removable by taking out the trim piece and four mounting screws, then rotating the top of the cluster forward to disengage the locating pins.