Cable barriers stop cross-median collisions, save lives

  • Article by: JIM ADAMS , Star Tribune
  • Updated: May 23, 2014 - 6:15 AM

The fences are installed where there is a likelihood of crossover collisions.

hide

The fence was installed along Hwy. 10 south of Main St. in Coon Rapids.

Photo: DAVID DENNEY • david.denney@startribune.com,

CameraStar Tribune photo galleries

Cameraview larger

Simple steel sentinels will be on duty this Memorial Day weekend, protecting Minnesota motorists at minimal cost.

They are the stubby cable fences now strung along almost 400 miles of Minnesota highways to prevent careening vehicles from crossing medians into oncoming traffic.

During a decade of service, they’ve done a sterling job, officials say. No fatal cross-median crashes have occurred where the cables are in place, said Kevin Gutknecht, communications director for the Minnesota Department of Transportation (MnDOT).

The first cable fence was installed in 2004 along Interstate 94 between Maple Grove and Rogers. Before then, that stretch had five fatal cross-median crashes, Gutknecht said. There have been none since.

“We install cable barriers where there is a high likelihood of crossover crashes, which are likely to be severe or fatal,” Gutknecht said.

Crash rates, speed and traffic volume are among the factors considered. Highway engineers also look at the width and slope of the median and future road construction plans.

Gutknecht said federal crash tests have shown that high-tension cable barriers are more than 90 percent effective in keeping vehicles on the correct side of medians.

“The statistics speak for themselves,” he said. “When a cable median barrier is installed, it reduces cross median head-on crashes almost completely. The cross median head-on crashes are often life-changing or fatal. The barriers are very effective and have saved lives.”

State Patrol spokesman Lt. Eric Roeske said it’s hard to quantify prevented crashes. But “every time they [cables] are hit, there is potential for a crossover crash,” he said.

Gutknecht said the best evidence of the 42-inch-tall barriers’ effectiveness is the damage they absorb: downed posts and cables that have kept out-of-control drivers from going across medians.

Cable barriers have been struck more than 440 times since 2009, when MnDOT began collecting such data. The resulting damage has cost about $498,000 to repair, Gutknecht said.

The state has 390 miles of cable fences, up from 116 at the end of 2008; about 166 miles are in the metro area. The latest cable barrier is being installed in Woodbury along I-94. Fences also run along Hwy. 36 in Roseville, Hwy. 252 in Brooklyn Center and Crosstown Hwy. 62 in Edina.

MnDOT says the cables cost up to $150,000 per mile to build, about a third of the cost of concrete barriers. The state spends about $7,000 per mile to repair damaged cable fences in the metro area. It recovers much of that from insurers of the vehicles involved.

One downside of the cables is that they often cause significant damage to vehicles whose drivers might have been able to regain control in a grassy or snowy median. But officials think that consequence is outweighed by what the cables prevent.

When an uncontrolled vehicle goes into the median, “the risk of crossing into oncoming traffic and causing life-changing injury or death is very high statistically,” Gutknecht said. “It’s a trade-off between property damage versus injuries and death. When there’s a head-on crash there is also property damage.”

How they work

The cables are bolted to concrete anchors at each end to keep them taut. They are strung between steel posts, which slide into buried concrete sleeves.

When hit, the posts are designed to snap off and the cables flex outward with incoming cars, absorbing the kinetic energy. Then the cables swing back, forcing the vehicle back onto the highway shoulder.

  • get related content delivered to your inbox

  • manage my email subscriptions

ADVERTISEMENT

Connect with twitterConnect with facebookConnect with Google+Connect with PinterestConnect with PinterestConnect with RssfeedConnect with email newsletters

ADVERTISEMENT

ADVERTISEMENT

ADVERTISEMENT

ADVERTISEMENT

ADVERTISEMENT

question of the day

Poll: Do you agree with the NFL decision to deny Adrian Peterson's appeal?

Weekly Question

ADVERTISEMENT

 
Close