UK investigators recommend disabling Honeywell emergency locator beacons in Boeing 787s

  • Article by: CASSANDRA VINOGRAD , Associated Press
  • Updated: July 18, 2013 - 5:35 PM

LONDON — British air safety officials said emergency transmitters on Boeing 787s should be disabled after finding that one of the squat orange boxes was the only thing with enough power to start a fire in the scorched tail section of a 787 parked at Heathrow airport last week.

The Air Accidents Investigation Branch also recommended that the U.S. Federal Aviation Administration and other regulators carry out a safety review of similar systems in other types of aircraft.

The recommendations in the report issued Thursday aren't binding. The FAA said it will take them under advisement but didn't take any other immediate action.

Boeing supported the recommendations. Its shares rose nearly 3 percent in regular trading. That's about where they were Friday, when investors saw images of a smoking 787 and feared a repeat of the battery problems that led to the planes being grounded earlier in the year.

But in a reminder of how sensitive the market remains to 787 issues, the shares fell 2 percent in after-hours trading after a Japan Airlines 787 flight returned to Boston's Logan Airport because of a possible fuel pump issue. There have been a number of similar minor incidents since the planes resumed flying in late April.

Investigators said Thursday that it was not clear if the fire was caused by the transmitter's lithium-manganese dioxide batteries or a short near or around the transmitter, but recommended that the FAA switch off the Honeywell transmitter in all Boeing 787s "until appropriate airworthiness actions" can be carried out.

A spokeswoman for the investigative branch said the easiest way to make the transmitter systems "inert" — as set out in their recommendations — would be to take out their batteries.

The FAA said it is reviewing the AAIB's recommendation "to determine the appropriate action."

Boeing called the recommendations "reasonable precautionary measures" and said it was working with regulators to take appropriate action in response.

Honeywell said "Temporarily addressing the (transmitters) on Boeing 787s as a precautionary measure is prudent." Honeywell said it doesn't expect any noteworthy financial impact as a result. Sahres of Honeywell International Inc. rose 53 cents to close at $82.97.

Honeywell has made 6,000 of these transmitters and they're used in a wide range of planes, the report said. All 68 of Boeing's 787s have them. So far, the July 12 fire is the "only significant thermal event" for those transmitters, the U.K. report said.

However, the investigators noted that large passenger planes don't usually have fire detection or suppression gear in the space above cabin ceilings, "and had this event occurred in flight it could pose a significant safety concern and raise challenges for the cabin crew in tackling the resulting fire," the report said.

Boeing spokesman Marc Birtel said that the transmitter isn't required by U.S. federal aviation laws, but is required by some foreign regulators for their airlines or their airspace.

Birtel said the transmitter, which helps with search and rescue operations, takes about an hour to remove from a 787.

The locators are activated in a crash and send a signal that satellites use to calculate the location of the plane.

The locaters are helpful in certain types of crashes, but of little value in others. They're most helpful in a crash in a remote area on land, where rescuers might have a hard time finding the wreckage. They're irrelevant for crashes where someone can see the plane, like the Asiana crash in San Francisco earlier this month. And they're of little help if a plane crashes in water, because it will "sink with the aircraft and be rendered useless," according to a 2005 report on emergency transmitters by a committee of the International Civil Aviation Organization.

They're not the only emergency transmitters on most planes. Some life rafts have their own, which are activated by salt water. And "pingers" attached to the flight data recorder and cockpit voice recorder also send out a signal that searchers can use.

Honeywell's Rescu406 AFN is designed to be used for planes flying over land, according to the company's sales brochure. Its battery is designed to last about 50 hours once it's activated. The orange, aluminum transmitter is the size of a squat loaf of Italian bread.

  • get related content delivered to your inbox

  • manage my email subscriptions





Connect with twitterConnect with facebookConnect with Google+Connect with PinterestConnect with PinterestConnect with RssfeedConnect with email newsletters